Ford should be very glad that there was not an accident at 70 mph. 2005 ford 500 shuts off while driving I have a busted motor mount and transmission mount on a 2005 Ford Five Hundred just as of yesterday here in Memphis it has started to warm up so I had my a/c on yesterday and when in operation while at slow speeds or at stop light the car will idle rough and start shutting on and off for about a millisecond. Yesterday, while I was driving the engine shut off, and the dashboard stated to look at gauges. The contact owns a 2005 Ford Five Hundred. When stopped at a light for instance the idle speed becomes low and sometimes stalls. I bought from original owner, low mileage (they upgraded). I again did the battery disconnect last night, and the car is operating normal today, but I'm sure it will recur shortly. The engine light went full and I lost power completely, with barely enough notice to pull off the highway. It took at least three tries to get the truck restarted. I am so glad my baby and kindergartener weren't in the car at this time! Something has to be draining the battery but we cannot figure out what it is. 2005 ford: five hundred that stalls..scanned..few seconds..dies all problems of the 2006 Ford Five Hundred When I first start my car its slow to give power, often when I drive it on the street itll just lose complete power and die down. by racingrush Wed Nov 03, 2010 3:59 am, Post I had this car repaired twice at a professional mechanic shop that cost me thousands of dollars. It began with the 12 volt not working. Thanks for the update. Other times, it would not work at all. The repair of the whole cluster panel is not cheap. The contact stated that while driving 10 mph, the vehicle stalled without warning. It should be a recall major safety violation. Used a different key next day, drove to work,home & out to run errands. Marcus, the service manager informed me a new wiring harness was now needed since the original one was melted by the PCM shorting out. Has this guy ever hear of stored fault codes? Still no fix. Can I Just Install A Fuel Pump Outside The Tank? This process repeats on and off over time. The dealer cannot figure out what is causing the battery to drain. SOLVED: Ford 500 - 2005 - The entire dash (all gauges) wen - Fixya it is extremely dangerous! Five Hundred Instrument Cluster Goes On and Off | Ford Forums When you start the car and let it set it will run for a few minutes then shut off. Ford Five Hundred Vehicles With This Problem 3 model years affected 2005, 2006, 2007 Average mileage: 126,054 (1-300,000) Check Engine Light Diagnosis & Testing : $88 -$111 The average cost for a Ford Five Hundred Check Engine Light Diagnosis & Testing is between $88 -$111. In the morning, look down into the hole. The manufacturer was notified of the failures, but no solution was offered. Ford Five Hundred Vehicles With This Problem - RepairPal The vehicle had random acceleration while at full stopped. This car has had so many issues, never again will I buy a FORD!! Proceeded back onto highway for about 2 miles. And now the dash shows check engine and reactions control and abs lights. I Was Driving One Day And My 1994 Ford Aerostar 3.0 V6 Suddenly Lost All Power And Would Not Start After. CK Engine light came on and started flashing. It's acting like bad alternator. I had it towed to the shop and low and behold it is the computer and catalytic converter so far and the mechanic states he hasn't seen anything like this since car is in good shape. I had to push the break as hard as I could to keep it from crashing into the store! Had This Problem Approx 1 Yr Ago. I can't afford repairs or a new car. wrench light comes on while im driving i turn car off start it back up starts fine. The contact owns a 2005 Ford Five Hundred. The manufacturer was not made aware of the failure. I do not think it should be my responsibility to pay for this since the part was recalled !!! The vehicle was not repaired. They told me all costs would be upon myself and that I can take it to a local dealership to get it looked at and fixed. Fuel Pump Problems: Car Stalls While Driving. Code Is P0191, - 2CarPros This needs to be investigated immediately before something terrible happens to someone. Find solutions to your toyota ecu reset procedure question. The contact owns a 2006 Ford Five Hundred. Now it cuts off while driving and reverse light on while dash is out 0 replies Report Answer Get it fixed today at a shop near you No hint that there was a problem before major mechanical problem. last month in January my Five Hundred had other issues. I called Ford to let them know that this has happened 4 times now and it is a MAJOR safety issue! I have a 2002 f250 5.4 and while I am driving it just cuts off. Still have a short somewhere . I was driving on freeway to pick my child from daycare when all the sudden the car stalled out. While reversing my car it will all of a sudden accelerate quickly on its own, I immediately step on the brakes and my car stalls. We were going approximately 45 miles an hour on a two lane road through the mountains when my Explorer decides to turn off. If this is happening to Explorers, Freestyles, Mustangs and many other makes and models maybe the throttle body assembly was made by the same mfg. There was bumper to bumper traffic on a hot day. This happens frequently almost daily in the summer. While driving about two weeks ago, the little wrench light came on and I lost power. What if I was at a gas station when this happened when their happened to be some petrol-vapor present. Lossing everything including powerstearing. Car will be driveing 55 and completely shut off. Our harness is an upgraded, direct replacement for the GM 15862656 and the AC Delco PT2195. The time yesterday, I was in a residential area, so I was not going that fast. Now the car is sitting in my garage because of the fuel pump not functioning and does not make that sound anymore when you turn the key on. I managed to get the dead metal off the road and into a store parking lot. It will surge making slow turns and surge when put into drive. a sodering defect or electrical short draining battery, it's obviously a vehicle defect. 2005 Ford Explorer Engine Stalls/Shuts Off While Driving While driving the car exhibits the following symptoms: dies for anywhere from 10-45 seconds, regain power and continues to work. The car is essentially un-drivable, because we cannot count on it to get to us work on time or safely. problems related to electrical system (under the electrical system category). Of course the coverage ended on 03/31/2013. Worst car ive ever bought second major incident that has happend since I got yhe car. Not only was it annoying, but I could not see my speed nor my gas gauge. Shutting off while driving! No start! Shutting off while driving! - YouTube I had to press brake hard to prevent moving hitting car in from of me. The vehicle was taken to the dealer where the contact was awaiting a full diagnosis of the failure. The dealer was notified of the issue but the vehicle was not repaired. Before I buy another vehicle, I'll be sure to check online to discover how well the manufacturer took care of problems. I Was Driving It On The Hwy When The Truck Just Turned Off. also, check the battery. I am having this repaired at the moment. While driving approximately 70 mph, all of the gauges on the instrument cluster stopped functioning and displayed readings of zero. There is something mechanically wrong with this car. I always liked Fords, but I don't know now. When we try to restart the car it will sputter and die again. I see someone already pointed out no recall on this problem. Cruise does not work. I have looked my car up to see if it has a recall but none are given. I had to carpool for about a week, and the warranty did not cover the problem. I bought this car in May of 2009. Unless of course while I am driving up or down a steep hill. by tmac1180 Mon Nov 01, 2010 7:14 pm, Post It was very scary. I got back in the car turned the ignition and after a few seconds it started and I could tell it was only running on 4 cylinders instead of 6. This process repeats on and off over time. Pmb. The contact was able to shut off and restart the vehicle in order to operate normally. However, I'm not really surprised about that. DANGEROUS!!! I had no warning was in bad traffic from a collision just up ahead when the car just died. Kw. Engine Shuts Off While Driving - Ford F150 Forum - Community of Ford It was very cold and snowy out. When this happens the reverse lights come on even when in drive. Total repair cost $2,700. statistics and reliability analysis of Ford Five Hundred based on all problems reported for the Five Hundred. 2022, CarProblemZoo.com All rights reserved. I only had it a month and the check engine light came on. Just because the check engine light isnt currently on, does NOT automatically mean there are not stored fault codes to retrieve. The failure occurred intermittently while driving at any speed. Please note that whenever the vehicle is on park and put into reverse, the higher acceleration takes place. So now were waiting to see what Sat. 2022, CarProblemZoo.com All rights reserved. The contact stated that while driving approximately 55 mph, the vehicle began to jerk violently and responded as though it would stall. . I was driving 35mph and all of a sudden my car had no power, I gave it gas and it would growl but no power. The fire department extinguished the fire; however, the fire erupted again and would not stop until the battery was disconnected. On the dash board "fail safe engine mode" appears on my console. The most common reasons a car shuts off while driving are a bad crankshaft position sensor or fuel supply problems. Are you positive its not something kinda weird- like a key falling out of just a touch? Car Won't Start When I Turn The Key I Here It Start And Then It Stalls Out. Consumer stated the left front head light caught on fire spontaneously while having been parked for 30 minutes in the garage and engine was off. I was at red light person crossing road I was I. It was very cold and snowy out. So, OPTION A..get a junkyard to cut off the end for $50 and splice/heat shrink on to existing cable. Looking at it, I could see it was the security light on the bottom side of the mirror; it was completely melted and fused to the mirror housing- a bubbly mess of plastic. Ford Forum is a community to discuss all things Ford. The vehicle had not been repaired. The vehicle was taken to a local mechanic who lubricated a component (the contact was unsure of what component) but the failure continued. I have owned my 2006 Ford 500 for 5 yrs and have had and issue for the last 2 yrs. theft light killing car randomly - Ford Truck Enthusiasts Forums The engine was still running and would accelerate. Ford House Said The Fuel Pump Was Bad Where Is The Fuel Pump Located In A 2000 Ford Excursion V10. Upon initial inspection I fount the car was throwing the code p0351 I cleared all faults and problem went away weks went by and problem started again but more sever during normal operation the car started shaking and shifting erratic I then came upon some k formation as to a recall Ford put in place stating improper calibration of pcm and tcm cause unnecessary interaction I the electrical system and malfunction of the vehicle. It often happens on the highway, but also on residential streets and at all speeds. This is dangerous; unable to tell speed! I'm Sick, Frustrated, angry, about to lose my job, what else? I've seen more electrial issues that turned out to be a weak battery. The extended warranty company also refused to honor the warranty also. I will not be buying a Ford ever again. They told me it would run like $80 for each coil plus $800 for the circuit board on top of labor if that's all that is wrong with it. I will never buy another Ford vehicle ever again!!!!!! Powered by Discourse, best viewed with JavaScript enabled. The vehicle also will shut off while I am going down the road and every time it does the THEFT light is coming on as the problem starts. I did not receive this notice and should still be able to get this repair done for free. Update from Apr 24, 2015: I want this moved to computer_PCM_failure (91 complaints) instead of in the engine section. For a better experience, please enable JavaScript in your browser before proceeding. 2006 Ford Five Hundred Engine Problems | CarComplaints.com Im afraid for the safety of my fellow drivers on the at night . A few times it worked for short periods of time. 6.0L Power Stroke Diesel - 6.0 randomly shuts off - 04 with 170k miles. The rpm's were low and it would idle rough and surge from low to high, I tried hitting the gas pedal and the car stalled! Thanks for listening. 3 Recalls for 2005 FORD Five Hundred The contact owns a 2005 Ford Five hundred. See Filled up with gas on Friday evening. - YouTube No start! I came around and peered in behind the actual mirror part; the fire had just gone out. From and I. The dealer was not contacted and the manufacturer was not notified of the failure. Sometimes the car will stall when the rpm's are dropping down. It is now parked there and when I start it the ECM light comes on. It turns out it is a faulty instrument cluster, just like the TSB mentioned. After all of this car still gave check engine and wrench light and car still stalled out and had no power. Then I wrote them a letter and here is the last line of the letter they sent me " Thank you for contacting Ford Motor Co. We are sorry that we were not able to meet your expectations.